thejoe Ford Explorer

Ford Explorer recalls

84 recall campaigns, model years 2015 to 2025. Each lists the fault, the risk, and the fix you are owed.

84Campaigns

2015–2025Years affected

0Do-not-drive

Check your own car in one step

Your VIN is on the dashboard by the windscreen. It is on your insurance card too. Put it into nhtsa.gov/recalls. You get the open recalls for your exact car. The repair is free. Most recalls never expire.

What keeps failing

System	Campaigns
Back Over Prevention	33
Power Train	24
Seats	19
Structure	17
Suspension	16
Equipment	15
Fuel System, Gasoline	10
Seat Belts	9

Every campaign

The text below is quoted from NHTSA word for word.

Engine And Engine Cooling:engine

16V183000 · reported 31/03/2016

The fault: Ford Motor Company (Ford) is recalling certain model year 2015-2016 Lincoln MKC vehicles manufactured November 25, 2013, to January 25, 2016, and 2016 Ford Explorer vehicles manufactured October 20, 2014, to January 28, 2016. The affected vehicles are equipped with 2.3L GTDI engines and engine block heaters. These engine block heaters have elements that may overheat while plugged in.
What it can cause: Overheating of the engine block increase the risk of a fire.
The fix: Ford will notify owners, and dealers will replace the engine block heater, free of charge. Dealers will also inspect and replace the electrical cord, as necessary. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S14. Note: Owners should not use the engine block heater until the vehicle has been remedied.

Electrical System:wiring

19V687000 · reported 30/09/2019

The fault: Ford Motor Company (Ford) is recalling certain 2020 Ford Explorer vehicles equipped with 2.3L or 3.3L engines. The wiring harness may not have been properly secured and may contact the air conditioner compressor (A/C) pulley, potentially damaging the harness or the A/C belt.
What it can cause: The A/C pulley may rub through the wiring harness insulation and contact the unfused battery positive wire, resulting in a short circuit, increasing the risk of a fire.
The fix: Ford will notify owners, and dealers will install a tie strap to the wiring harness at the hand shock tower clip, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S32.

Seats

17V767000 · reported 29/11/2017

The fault: Ford Motor Company (Ford) is recalling certain 2016 F-150 and Explorer vehicles. Loose power seat adjuster pivot bolts may cause the front seat cushions to detach and not properly restrain the seat occupant in the event of a crash.
What it can cause: In the event of a crash, a seat occupant that is not properly restrained has an increased risk of injury.
The fix: Ford will notify owners, and dealers will inspect the tightness of the power seat track upper pivot link bolt, either applying threadlocker or replacing the lift link and hardware, free of charge. Interim letters are expected to go out January 15, 2018. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S40.

Fuel System, Gasoline:storage:tank Assembly:mounting

15V605000 · reported 28/09/2015

The fault: Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Lincoln MKS, and 2016 Ford Explorer vehicles manufactured on July 24, 2015. During vehicle production, the fuel tank attachment bolts may not have been properly tightened. As a result, the fuel tank straps may fracture and the fuel tank could separate from the vehicle.
What it can cause: If the fuel tank separates from the vehicle, a fuel leak may occur, increasing the risk of a fire.
The fix: Ford will notify owners, and dealers will tighten the fuel tank attachment bolts, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S26.

Seats:front Assembly:recliner

19V633000 · reported 28/08/2019

The fault: Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
What it can cause: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
The fix: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

Wheels:hub

17E048000 · reported 28/08/2017

The fault: Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
What it can cause: A loss of the wheel or wheel end can increase the risk of a crash.
The fix: Ford will notify the distributors of the hubs specifying that they are to only be used on drive axles. It is believed that none of the hubs were purchased from Ford dealers for the incorrect application. Owners may contact Ford customer service at 1-866-436-7332.

Steering

17V530000 · reported 28/08/2017

The fault: Ford Motor Company (Ford) is recalling certain 2017 Explorer, Taurus and Police Interceptor Utility and Sedan vehicles. The steering gear heat shield fasteners may corrode, allowing the heat shield to detach.
What it can cause: If the heat shield detaches, the steering gear may overheat, increasing the steering effort required by the driver, especially at lower speeds, and increasing the risk of a crash.
The fix: Ford will notify owners, and dealers to inspect and replace the heat shield fasteners as needed, free of charge. The recall began on September 13, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S23.

Seats:front Assembly:recliner

16V475000 · reported 28/06/2016

The fault: Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
What it can cause: The seat back may not adequately restrain the occupant during a crash, increasing the risk of injury.
The fix: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall begin on August 18, 2016. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 16C11.

Back Over Prevention:display Function

23V305000 · reported 28/04/2023

The fault: Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer Police Interceptor Utility vehicles equipped with a 12.1-inch Integrated Computer Screen (ICS). When the Display On/Off Button is used to turn the display to "Off" prior to placing the vehicle in reverse, the backup camera rearview image will not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
What it can cause: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.
The fix: Dealers will update the ICS software, free of charge. Owner notification letters were mailed July 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C14.

Back Over Prevention:software

25V442000 · reported 27/06/2025

The fault: Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
What it can cause: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
The fix: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

Engine And Engine Cooling:engine:hard Parts Internal/mechanical

26V343000 · reported 27/05/2026

The fault: Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer, Ranger, and Bronco vehicles. The engine may fail, which can result in a loss of drive power.
What it can cause: A sudden loss of drive power can increase the risk of a crash.
The fix: Dealers will replace the engine long block, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2026. Additional letters will be sent once the remedy is available, anticipated in November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S35. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 28, 2026.

Suspension:rear

16V245000 · reported 26/04/2016

The fault: Ford Motor Company (Ford) is recalling certain model year 2014-2015 Ford Explorer vehicles manufactured January 17, 2014 to May 31, 2014. The affected vehicles may have improperly welded rear suspension toe links that may fracture.
What it can cause: A fracture of the rear suspension toe link may result in a loss of steering control, increasing the risk of a crash.
The fix: Ford will notify owners, and dealers will replace the rear suspension toe links, free of charge. The recall began on November 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S18.

Back Over Prevention:software

24V801000 · reported 25/10/2024

The fault: Ford Motor Company (Ford) is recalling certain 2025 Explorer and Lincoln Aviator vehicles. The rearview camera image may fail when the vehicle speed reaches 10 MPH or greater. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
What it can cause: The loss of the rearview camera image while in reverse can reduce the driver's rear visibility, increasing the risk of a crash.
The fix: The accessory protocol interface module (APIM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C34.

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

23V597000 · reported 25/08/2023

The fault: Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles equipped with 2.3L GTDI engines. The turbocharger oil supply line may be damaged, which can result in an oil leak inside the engine compartment.
What it can cause: An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire. In addition, the loss of oil can result in an engine stall, increasing the risk of a crash.
The fix: Owners are advised to park and shut off the engine as soon as possible if they see an oil pressure warning light or smoke coming from the engine compartment. Dealers will replace the turbo oil supply line assembly, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S50.

Fuel System, Gasoline:storage

20V730000 · reported 24/11/2020

The fault: Ford Motor Company (Ford) is recalling certain 2020 Explorer vehicles equipped with 2.3L engines and 19 gallon fuel tanks. The fuel tank inlet check valve may not be fully welded to the fuel tank shell.
What it can cause: An incomplete weld securing the inlet check valve to the fuel tank shell could result in a substantial fuel leak during a crash, increasing the risk of fire.
The fix: Ford will notify owners, and dealers will replace the fuel tank shell, free of charge. The recall began December 8, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S68.

Visibility:windshield

25V730000 · reported 24/10/2025

The fault: Ford Motor Company (Ford) is recalling certain 2025-2026 Lincoln Corsair, Lincoln Aviator, and Explorer vehicles. The windshield glass may have visible air bubbles, which can obscure the driver's visibility. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 205, "Glazing Materials."
What it can cause: Reduced visibility while driving can increase the risk of a crash.
The fix: Dealers will inspect and replace the windshield as necessary, free of charge. Owner notification letters were mailed November 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C60. Vehicle Identification Numbers (VINs) involved in this recall become searchable on NHTSA.gov beginning October 27, 2025.

Parking Brake

15V464000 · reported 24/07/2015

The fault: Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Ford Flex, and Lincoln MKS vehicles manufactured May 4, 2015, to May 23, 2015, Lincoln MKT vehicles manufactured May 4, 2015, to May 21, 2015, and 2015-2016 Ford Explorer vehicles manufactured May 4, 2015, to May 23, 2015. The affected vehicles have a parking brake that may not fully engage when applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
What it can cause: If the parking brake does not fully engage and the transmission is left in a gear other than 'Park' while on a slope, the vehicle may roll away, increasing the risk of a crash.
The fix: Ford will notify owners, and dealers will test the operation of the parking brake system, and if necessary, replace the parking brake control assembly, free of charge. The recall began on September 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C07.

Power Train:automatic Transmission

26V402000 · reported 24/06/2026

The fault: Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
What it can cause: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.
The fix: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.

Structure:frame And Members

22V454000 · reported 24/06/2022

The fault: Ford Motor Company (Ford) is recalling certain 2022 Lincoln Aviator and Ford Explorer vehicles. The engine rails may have been improperly heat-treated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and 301, "Fuel System Integrity."
What it can cause: Improperly heat-treated engine rails may reduce the vehicle's structural protection in a crash, increasing the risk of injury. In addition, an engine rail may detach and contact the road while driving, increasing the risk of a crash.
The fix: Dealers will perform an engine rail strength test and replace the rails as necessary, free of charge. If the engine rails require replacement, owners will have the option for a vehicle replacement or buyback. Owner notification letters were mailed August 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C13.

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

23V199000 · reported 24/03/2023

The fault: Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
What it can cause: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
The fix: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

Back Over Prevention: Sensing System: Camera

20V575000 · reported 23/09/2020

The fault: Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
What it can cause: Reduced rearward visibility can increase the risk of a crash.
The fix: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

Engine And Engine Cooling:engine:hard Parts Internal/mechanical

24V635000 · reported 23/08/2024

The fault: Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
What it can cause: A loss of drive power increases the risk of a crash.
The fix: Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.

Fuel System, Gasoline:fuel Injection System:injectors

24V634000 · reported 23/08/2024

The fault: Ford Motor Company (Ford) is recalling certain 2023 Lincoln Corsair, 2023-2024 Escape, 2024 Mustang, and 2025 Explorer vehicles. The fuel injectors may have been assembled without O-ring support discs, which can result in a fuel leak.
What it can cause: A fuel leak in the presence of an ignition source increases the risk of a fire.
The fix: Dealers will install new fuel injector O-rings and O-ring support discs, free of charge. Owner notification letters were mailed on October 7, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S54.

Air Bags:side/window:curtain

21V652000 · reported 23/08/2021

The fault: Ford Motor Company (Ford) is recalling certain 2021 Explorer and Lincoln Aviator vehicles. The side air bag attachment weld studs could detach during the deployment of the side air bag, resulting in an improper deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard 214, "Side Impact Protection".
What it can cause: Improper deployment of a side air bag increases the risk of injury during a crash.
The fix: Dealers will replace the side air bag assemblies, free of charge. Owner notification letters were mailed September 10, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C19.

Structure:body

25V347000 · reported 23/05/2025

The fault: Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
What it can cause: Door trim that detaches while driving can create a road hazard, increasing the risk of a crash.
The fix: Dealers will repair the B-pillar trim, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2025. A second notice will be sent once the final remedy is available, anticipated November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S53.

Back Over Prevention: Sensing System: Camera

23V022000 · reported 23/01/2023

The fault: Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
What it can cause: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
The fix: Dealers will update the image processing module (IPMB) software, free of charge. Interim owner notification letters informing owners of the safety risk were mailed April 25, 2023. Owner notification letters were mailed February 13, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S02. This recall expands and replaces NHTSA recall number 21V-735. Vehicles previously repaired under 21V-735 will need to have the new remedy performed.

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

16V925000 · reported 22/12/2016

The fault: Ford Motor Company (Ford) is recalling certain model year 2016 Ford Taurus, 2016-2017 Ford Flex, Lincoln MKT, 2017 Ford Explorer and Ford Explorer Police Interceptor Utility vehicles equipped with 3.5L GTDI engines. Improperly brazed turbocharger oil supply tubes may leak oil on engine components.
What it can cause: An oil leak, in the presence of an ignition source, increases the risk of a fire.
The fix: Ford will notify owners, and dealers will inspect, and if necessary, replace the turbocharger oil supply tubes, free of charge. The recall began on January 31, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S46.

Back Over Prevention:software

21V735000 · reported 22/09/2021

The fault: Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer, Lincoln Corsair, and Lincoln Aviator vehicles equipped with 360-degree cameras. The video output may fail, preventing the rearview camera image from displaying.
What it can cause: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
The fix: Dealers will update the Image Processing Module (IPMB) software, free of charge. Owner notification letters were mailed November 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S44.

Exterior Lighting:tail Lights

25V543000 · reported 22/08/2025

The fault: Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. When towing a trailer, the tail lights on the trailer may fail to illuminate due to an improperly manufactured body control module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
What it can cause: Trailer tail lights that do not illuminate as intended can reduce visibility to other drivers, increasing the risk of a crash.
The fix: Dealers will replace the body control module C on vehicles with less than 9,000 miles. For vehicles over 9,000 miles, dealers will perform a functional check on the body control module C and replace it as necessary. Repairs will be performed free of charge. Aviator 2025 owner notification letters were mailed October 13, 2025. Explorer 2025 owner letters were mailed November 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C42.

Seats:front Assembly:recliner

17V332000 · reported 22/05/2017

The fault: Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
What it can cause: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
The fix: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.

Air Bags:critical Fasteners

20V497000 · reported 21/08/2020

The fault: Ford Motor Company (Ford) is recalling certain 2020 Explorer and 2020 Lincoln Aviator vehicles. The side air bag and/or seat back module attachments may not have been properly tightened in the front seat backs.
What it can cause: If the side air bag or seat back fasteners were not properly tightened, the side air bag deployment could be affected, increasing the risk of injury during a crash.
The fix: Ford will notify owners, and dealers will remove front seat back panels from one or both front seats (VIN-specific) and verify that the fasteners have been properly tightened, free of charge. The recall began September 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S48.

Suspension:rear

26V101000 · reported 20/02/2026

The fault: Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
What it can cause: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
The fix: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.

Back Over Prevention:software

26V165000 · reported 19/03/2026

The fault: Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.
What it can cause: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.
The fix: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.

Structure:body:roof And Pillars

24V031000 · reported 19/01/2024

The fault: Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
What it can cause: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
The fix: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.

Engine

20V788000 · reported 17/12/2020

The fault: Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer and Lincoln Aviator vehicles. The right hand motor mount fasteners may have been incorrectly tightened, and may loosen over time.
What it can cause: With a loose motor mount, motor vibration may cause the axle to disconnect from the engine and could result in loss of power, increasing the risk of a crash.
The fix: Ford will notify owners, and dealers will remove and replace the right hand motor mount fasteners, free of charge. The recall began February 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S72.

Seat Belts

26V159000 · reported 17/03/2026

The fault: Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.
What it can cause: A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.
The fix: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.

Power Train:automatic Transmission

25V020000 · reported 17/01/2025

The fault: Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.
What it can cause: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.
The fix: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

22V088000 · reported 16/02/2022

The fault: Ford Motor Company (Ford) is recalling certain 2022 Explorer and Lincoln Aviator vehicles. The fuel filler tube may detach during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 301, "Fuel System Integrity."
What it can cause: A detached fuel filler tube can result in a fuel leak, increasing the risk of a fire.
The fix: Dealers will install a fuel vapor line redundant locking clip, free of charge. Owner notification letters were mailed on April 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C02.

Suspension:rear

21V537000 · reported 15/07/2021

The fault: Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
What it can cause: A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.
The fix: Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.

Equipment:electrical:engine Block Heater

26V012000 · reported 15/01/2026

The fault: Ford Motor Company (Ford) is recalling certain 2016-2018 Focus, 2019 Explorer, and 2024 Explorer vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
What it can cause: An electrical short circuit can increase the risk of a fire.
The fix: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed February 13, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 16, 2026. This recall expands previous recall number 25V685.

Showing the 40 most recent of 84. The rest are on nhtsa.gov.

Source: NHTSA recalls API, retrieved 4 August 2026.

← All Ford models